Reviews

2007 Pontiac Solstice Mallet V8

More power than a Carrera S, less expensive than a base , lighter than a Z06. That’s a tall order, especially when you add a soft top and a stylish exterior. Too tall, in fact, for any manufacturer, but perfect for Chuck and Lance Mallett of Berea, Ohio. With nearly a decade of experience tuning Corvettes and Cadillacs under their belts and a family racing heritage rooted in the 1950s, these boys get what they want the old-fashioned way-by wielding heavy hammers.

The Pontiac Solstice depicted above is one of the first 1000 cars off the line. Chuck Mallett seized it from a South Carolina Pontiac dealer’s clutches with evil intent: to rip out the factory’s 2.4-liter Ecotec four-cylinder and pound in 400-hp’s worth of 6.0-liter LS2-Corvette-V-8, then add a “Mallett V-8 001” serial plate to the dash.

To squeeze eight cylinders into a four-cylinder hole, it was necessary to notch the right frame rail and shift the rack-and-pinion steering gear a tad. Two belly pans were altered to permit use of the stock V-8 exhaust manifolds and catalytic converters. While clearances are tighter than what GM condones, the installation is clean and neat thanks to the use of OE-style wiring and plumbing.

Twist the ignition key, squint your eyes, and the Solstice morphs into a Corvette convertible humming the standard V-8 rumble. The motor music is piped through a Corsa muffler, then out a single exhaust tip in the interest of stealthiness. Except for Mallett forged-aluminum wheels wrapped by 265/35YR-19 Michelin Pilot Sports and a few discreet Mallett badges, there’s nothing to give away the ruse.

Indulge the throttle, however, and the jig is up. Winding through the stock 3.91:1 axle ratio, first gear is useless except for those with a wheel-spin fetish. Second is almost as bad. But on a below-freezing, low-grip day, we did clock a 4.9-second 0-to-60-mph run by launching in second gear with engine rpm barely above idle, feathering the throttle until the tires finally hooked in the middle of third gear. Our 13.0-second, 114-mph quarter-mile pass should be a cinch to beat on a warm day.

The Mallett-ized Solstice rattles and rocks like no stock Pontiac. Stiffer springs, thicker antiroll bars, tighter Penske dampers, and larger hardware from Stainless Steel Brakes help keep the monster in line-sort of-but you shouldn’t shop here if you expect highly refined behavior.

If you’d be happy with a stealthy beast, act now, because the Malletts intend to build only 100 examples. Prices start at $20,000 (plus the core Solstice or Saturn Sky), not including the larger brakes, nineteen-inch footwear, double-adjustable dampers, and other options you’ll probably want. A two-year limited warranty (but no “Get Out of Jail Free” card) is included.

Comments
We’ve Temporarily Removed Comments

As part of our ongoing efforts to make AutomobileMag.com better, faster, and easier for you to use, we’ve temporarily removed comments as well as the ability to comment. We’re testing and reviewing options to possibly bring comments back. As always, thanks for reading AutomobileMag.com.